Product ID:705 TONER (SAVIN),4220
MSDS Date:10/29/1990
FSC:6850
NIIN:01-126-3103
Kit Part:Y
MSDS Number: BTKTQ

RICOH CO LTD

5 DEDRICK PL
WEST CALDWELL, NJ 07006-6304
US

Emergency Phone: 800-336-6737

Info Phone: 201-882-2000, 800-336-6737

Preparer: KRISTINA SAGE

Cage: 2Z665

SAVIN CORP.

12070 STAMFORD, CT 06904-2270 US

Telephone: 203-967-5000

Cage: 29382

HYDROTREATED HEAVY NAPHTHA

CAS: 64742-48-9

Fraction By Weight: 89%

WAX

CAS: 9002-88-4

Fraction By Weight: 6%

ACRYLIC POLYMER

CAS: 25068-63-7

Fraction By Weight: 3%

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 2-8%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9394

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE- MAY CAUSE EYE IRRITATION,
REDNESS. MAY CAUSE DRYING OF SKIN. INHALATION MAY CAUSE RESPIRATORY
TRACT IRRITATION. PRACTICALLY NON-TOXIC BY INGESTION. CHRONIC-
PROLONGED CONTACT WITH SKIN MAY CAU SE DRYNESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS IRRITATION, DRYING & FLAKING OF SKIN, REDNESS OF EYES,
COUGH, HEADACHE, DIZZINESS, LOSS OF COORDINATION, ABDOMINAL PAIN,
NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY AND SKIN
DISEASES MAY BE AGGRAVATED.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:REMOVE
CONTAMINATED CLOTHING. WASH SKIN WITH SOAP & WATER. EYE:FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. INHALED:REMOVE TO FRESH
AIR. PROVI DE OXYGEN/CPR IF NEEDED. ORAL:DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:125F,52C
Lower Limits:0.7
Upper Limits:6.5
Extinguishing Media:USE FOAM, DRY CHEMICAL OR CARBON DIOXIDE. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE-EXPOSED CONTAINERS
WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT MATERIAL SUCH AS SAND. PLACE IN CONTAINER
FOR DISPOSAL. PREVENT LIQU ID FROM ENTERING SEWERS, WATERWAYS OR
LOW AREAS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED AREA
AWAY FROM SOURCES OF IGNITION AND OXIDIZERS. KEEP CONTAINER CLOSED
WHEN NOT IN USE.
Other Precautions:ENFORCE "NOT SMOKING" RULES IN STORAGE AREAS. USE
EXPLOSION-PROOF EQUIPMENT. CLEAN CONTAMINATED EQUIPMENT THOROUGHLY
BEFORE STARTING ANY REPAIR WORK. AVOID CONTACT WITH EYES AND SKIN.
AVOID BREATHING VAPORS. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION (REFER TO 29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW PEL(S).
Protective Gloves:NITRILES RECOMMENDED
Eye Protection:SAFETY GLASSES/FACE SHIELD
Other Protective Equipment:IF EXCESSIVE SPLASHING IS EXPECTED, USE A
RUBBER APRON AND FACE SHIELD. PROVIDE EYEWASH STATION AND EMERGENCY
SHOWERS.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:F4. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. PART ONE, HAS
PNI A; PART TWO HAS PNI B, SAME NSN.

HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:356F - 374F
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Vapor Pres:<10 @ 77F
Vapor Density:>5
Spec Gravity:0.75
Viscosity:NOT KNOWN
Solubility in Water:NEGLIGIBLE, <0.1%
Appearance and Odor:BLACK LIQUID, FAINT PETROLEUM HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE AND CONCENTRATED OXYGEN
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAMES
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE AND OTHER DECOMPOSITION PRODUCTS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. ALL RESPONSE ACTIVITES MUST BE COMPLY WITH
HAZPOWER (29 CFR 1910.120).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.